2014 ford explorer ac blowing hot air

#1 I have a 2016 Explorer Limited. If there isnt enough oil added with the refrigerant or to the compressor itself if it was replaced, the internal components of the compressor will wear out and cease to function. @ Birdmedic, just tried that and have error codes 024/025. Absolutely ridiculous. Hold for a few seconds. Ford service departments s**k just want cash. Cabin air filter captures most of the dirt or other airborne particles, but some escape and fall on to the evaporator. It worked. Just like with low refrigerant, the AC in Explorer will blow warm air only if the AC system is overcharged with refrigerant. Thereafter I began to experience cold air blowing on drivers side but warm air on passenger side. It was an inexpensive part, but replacing this piece took a lot of patience. What about those (somewhat unpleasant!) During a recent oil change, the cabin filter was replaced. Sweat. This turns your blowers to the highest setting, the temperature to the coolest setting, and directs all of the airflow to the vents located on the dashboard. The blend door actuator is the component that controls the interior temperature of the car by mixing hot and cold air from the evaporator and the heater core. Once the leak has been found, this must be closed again by replacing the respective component. I do think I have to do that to remove that dash completly to say to access the motor if it is that in fact. Check the air blend motor functions and linkages for sticking. So Ford knew they had this problem a long time ago and didn't do anything about it accept change out the blend at a cost from 1200.00 to 1500.00 to it's costumers. Did not have time this weekend to troubleshoot further other than the diag codes. Code 24 and 25 are Blend Door failure codes. Atleast 3 times. We know Ford vehicles, This hinders the condensers ability to release heat as less air passes through the mesh, which results in poor cooling in the interior. Also I would need to rent a car and leave the car there for six hours for them to assess the problem. If only hot air comes out of the air vents, then the problem probably lies somewhere else. Last year we noticed that the heat for the passenger side in our 2014 Ford Explorer would not get hot. I bought this Explorer new in 2013. You can access the filter by following a few simple steps, as shown in the video. This can be done, for example, with a vacuum cleaner or a compressed air system, removing at least a large part of the visible dirt particles. It also puts unnecessary strain on the entire AC system which negatively impacts the fuel consumption. 194.140.192.8 If this sensor develops a defect, it will send incorrect values to the control unit and the AC compressor will not turn on. The door handle is coming apart, the AC blows hot on the passenger side, the spare tire rattlestons of little things too: the leather is cheap and wearing quickly, the SYNC is quirky and sometimes does not work at all, the radio does not go low enough to pick up a station I want ugh. The air flow from the vents is choppy and not smooth. It is very hot here in Texas and my kids are super hot. Several months forward and issue reappears, and this method doesn't seem to work. If you drive a 2014 Ford Edge,that might be that the climate control is blowing hot air out one side and cold air out the other. 1. Home Troubleshooting Ford Explorer AC not working causes and how to fix it. You can use power washer for cleaning, but make sure that its at low pressure setting, as high pressure can easily damage the delicate fins on the condenser. 2014 Ford Explorer Asked by Visitor in Greenwood, MS on April 03, 2019 Turned on AC getting cold air out of vents on drivers side. I'm very disappointed in Ford for these issues only after a couple of years of use, this is ridiculous. The AC uses the same type of relay as the horn, and swapping the relays doesn't help. Turned on AC getting cold air out of vents on drivers side. VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. A broken compressor is usually irreparable. There is no prescribed time for changing cabin air filter, but most manufacturers recommend a change after 10,000-20,000 miles. Both of these are at risk of clogging due to contamination, for example due to metal shavings from a failing compressor. I had to give a rating before I could send this message what kind of bull - - - - is this. 604-234 Blend Door Actuator Replacement:. The most common causes for AC blowing hot air in Ford Explorer are low or overcharged refrigerant, compressor malfunction, dirty condenser or evaporator coils, faulty blend door actuator, defective evaporator temperature sensor, bad AC pressure sensor, and bad fuse or relay. Phase 3 complete. Just have it refilled and you can drive with pleasant temperatures again. A clogged expansion valve or orifice tube will cause the AC to only blow hot air. Start by inspecting the condition of the cabin air filter on your Explorer. Temp gage is LO. Reply Like #9 04-22-2013, 01:11 PM . 91,000 MILES When AC is turned on, hot air is blowing from driver side vents and cold air from passenger vents. and after one final test to be sure the system is cooling properly, Passenger side is perfectly fine still. Has anyone else had this issue? Apparently this is a known problem that Ford and their dealerships have decided to ignore. Otherwise, the compressor will not run. I had set it to "HI" heat and it worked fine-on only the driver side. As a rule, there is no avoiding a change. 2023 Firestone Complete Auto Care. When the air conditioner in your 2013 Ford Explorer starts blowing hot air, you likely have a freon leak. The worst damage, however, is a failure of the AC compressor when it eats itself due to insufficient lubrication or a production error, metal chips form, which are distributed throughout the Explorers AC system. Will keep you posted. I have an eyelid stye, irritated and watery eye. Ford Forum is a community to discuss all things Ford. BUT ALL MOTOR COMPANY'S DO THIS ALSO, PROFIT OVER CUSTOMERS AND SCREW THEIR CUSTOMERS!!!!!!!!!!!!!!!! If your A/C system has a leak, well find and repair it. Smaller holes have to be localized by searching all components with a gas detector. The dash must come out to change the blend door actuator. Lake Mathews, CA, US. The driver's side would blow hot and cold and the passenger would only blow cold. What seems to make the problem better or worse? Cold air drivers sude, hot air on passengers side, Front windows passenger and drivers side window does not work. They said they can file the complaint and see if ford will take a percentage off the repair but was not hopeful since it's over three years old. to evaluate what repairs are necessary (if any). Glad to hear that it's fixed. He is a longtime contributor to Vehicle History and a member of the site's original content team when it launched. When we perform an A/C repair on your 2014 Ford Explorer, we'll also do an A/C evacuation and recharge. Check your vehicles owners manual or look under the hood to find the type of the refrigerant your vehicle uses. Most drivers find that following these steps provides a simple fix to problems with the Ford Edge HVAC system. Moved the door manually and still no change. A dirty filter causes the overall ventilation of the interior to deteriorate resulting in reduced cooling, heating and air flow. So I called my brother in law who was a automobile mechanic for FORD for 30 years and he does not know any thing was a problem in this model and Ford did not tell it's mechanic about this issue, so the only thing was to change the blend door and this was a cost of 1200.00 dollars. Temp gage is LO. Chris (aka- Moose) Ford Technician. Read on and find out. Resetting Your Climate Control The quick-fix for this problem (also described in the above video) might get your HVAC blowing correctly in seconds. Climate control worked great for approx. No matter what setting I used, passenger side continued to blow cold air regardless of temperature setting. The action you just performed triggered the security solution. If you drive your vehicle in dusty or polluted environment, the filter can get dirty much sooner than manufacturers recommendation. Ford certs and ASE Certs. Love the car and thanks for posting the above mentioned instructions. In addition to the vehicle make, model, and engine type, you usually also have to type in the Vehicle Identification Number (VIN). Thanks for the reply back. Yes the temp dial is on cold on both dials. It was some labor and would of been much easier with a 2nd person. Over time, grime, bugs and other small particles can build up on its surface and in the gaps of its mesh. When looking for the reason, you should always start with the most obvious cause, insufficient amount of refrigerant. Explorer Limited 2.3L Eco-Boost. Then, they'll perform an evacuation (also known as a discharge) on the entire system per Ford guidelines. Most refrigerants include a leak sealer that will seal small leaks in addition to filling the R134a freon. Firestone Complete Auto Care can! You can recharge your AC through the low-pressure port with a do it yourself AC recharge kit. For a better experience, please enable JavaScript in your browser before proceeding. If the fuse is blown, replace it with a new one with the specified amp rating. When the air conditioner in your 2017 Ford Explorer starts blowing hot air, you likely have a freon leak. A knocking noise could be another indicator of a bad blend door actuator on your Explorer, although its quite rare. If it's HOT like the heater is on, it's likely a stuck blend door (this is what I suspect by your description). This can happen due to a leak or if the AC has not been recharged for a long time. Well keep you informed. Going over it step by step: Press the defrost button and the power button at the same time Hold both buttons down for a few seconds Release Press the power button again Never had one and hopefully the last one. The AC pressure switch in Explorer detects and monitors the pressure of the refrigerant in the AC system. My local dealer wants $700 labor and Simply don't think it's worth it to go through the dealer. With the a/c on, feel the vapor return line under the hood by the firewall. Like, what exactly is going on here, and what do you do if that doesnt do the trick? After I received the estimate I went back to the dealer to discuss my options. Click to reveal The quick-fix for this problem (also described in the above video) might get your HVAC blowing correctly in seconds. So I gave a rating of 1 when it should be a negative 10 for the Ford Motor Company. Nothing but a money racket!! Have you actually looked and confirmed that the a/c compressor clutch Is kicking on and staying on, if so you can check freon level with a manifold gauge. So far so good. Over time, these particles build up on the fins and block the air flow through the evaporator, causing reduced air flow in the cabin and poor cooling. 2014 Ford Explorer 7.4 pretty bad Typical Repair Cost: $1,000 Average Mileage: 54,150 miles Total Complaints: 13 complaints Most Common Solutions: not sure (8 reports) replaced blend door. It initially blows cold air, then warm air for a few minutes, then blows cold again, and keeps on going back and forth between cold and warm. Finally, well recharge the A/C system with new refrigerant So what I'm saving is the Ford Motor Company lost a Ford buying costumer only. I had bought a used 2014 ford explorer xlt flex fuel 4wd from a used car dealer in ionia, mi. Finding these mostly very small leaks is often not easy. 37,779 satisfied customers. Bad AC pressure switch can be diagnosed with OBDII scanner. It is no surprise that this vehicle gets low marks for A/C in Consumer Reports. This went out last year in April with about 38k miles on it. Yes it is electronic temp control (sensors) and I hear the clutch kick in and stay on but will inspect physically also. With the tool connected, turn on the ignition. The most common symptom of faulty blend door actuator on Ford Explorer is a slight clicking sound repeatedly coming from under the dashboard. Will that help in your diagnosis. 10 minutes shy of 2 hours to reinstall dash and components. Anytime there is a problem with the temperature of the air conditioning system, it could be a problem with the blend door actuator. I further read the service manual and maybe for a few more bolts and disconnecting the core hoses I could if made installing the new blend door much easier. It was chilly and a bit foggy outside. This meant that all last winter the passenger would be freezing if the heat was blowing at all.We diagnosed the problem as a bad or stuck blend door actuator. The car heating mechanism entirely depends on whether the levels of coolant are sufficient. What to do??? Just started. Problem is due to a fault in the air blend doors and from symptom description, your system should be equipped with dual-zone meaning there are 2 separate electrical blend door motors an the driver side seems to be stuck in heater mode. For every complaint posted here, and am sure there are hundred s that are not reported. Ford Explorer. Then, theyll perform an evacuation (also known as a discharge) on the entire system per Ford guidelines. Remember to kiss (keep it simple stupid) I would hate to have to access the blend door, after you have checked the easy stuff, I would stand in conjunction with skinner. In most cases, the entire dashboard has to be removed before you can access the evaporator. Well I spent 3 days trying to get heat to drivers side. That could be the result of a dirty cabin air filter (an easy fix!) Same problem with heat and air Reset worked for awhile ! Now that the weather is getting cold, I'm going to have to freeze until I'm able to afford to get the heater repaired!!!! Release, then push the power button once more. 37 % of the time it's the. Check all the relevant fuses and relays related to the air-conditioning system in your Explorer. The most common causes that hinders normal operation of air conditioning system on your Ford Explorer are dirty cabin air filter, refrigerant leak, dirty or clogged condenser, dirty or clogged evaporator, bad blower motor, defective compressor, faulty blend door actuator or any fault in the electrical system. This data is sent to the control unit which turns the compressor on or off based on these readings to maintain proper operating temperature of the evaporator. The cabin air filter captures most of the dirt or other airborne particles, but some particles escape and can get lodged on to the evaporator. It consists of moving parts that convert what is actually a gaseous coolant into liquid this is how your vehicle is cooled. So after 2 to 3 months of investigation and having no heat in the winter time a watched a video from a backyard mechanic, and that was to do the same thing that was mentioned in the article. The Explorer has about 105,000. Now instead of going to the Ford Dealership and buy a Ford products, I go to all different dealership, and look up complaints negative about any vehicle and Decide What to buy. you have been a member of the forums for a long time. This can have different causes. There are several causes for AC only blowing hot air in Explorer, which we will cover in this article. Recently involved in rear end collision. now.That dash with the steering column on it made for a heavy item to install and align correctly by myself. Thank you so much for sharing the detailed information. Cost to repair this was $756.00. What these are and what you can do about it, we explain in this article. This website is using a security service to protect itself from online attacks. A clogged or leaking condenser can also be the reason for air-conditioning not working properly on your Explorer. The local service center told me I needed all new parts since it was the compressor of my AC unit. If there is no air flow or reduced air flow from the vents on your Ford Explorer, bad blower motor could be the culprit. 2023 Vehicle History Inc. All Rights Reserved. problem same, even if I turn off dual model. It is important that you enter this 100% correctly, otherwise the result of the search may be inaccurate. I spent many hours and $50.00 replacing the actuator. Ugh. Sounds to me like this isn't your first rodeo. Your steering wheel feels like lava. Blend door motor. This check includes a visual inspection, performance test, and pressure and leak test. 23 years with Ford specializing in drivability and electrical and AC. To reset the climate control in your 2014 ford explorer vehicle, turn your ignition key to the "on" position and depress the ac and heater buttons at the same time, release and depress the heat only until a reset is performed. I replaced the complete control panel,fan,reastate,air conditioning control. Larger leaks may already be heard or you can find them with a leak detection spray. Climate control module is the brain of the air-conditioning system in your Ford Explorer, responsible for controlling all the components in the system. Do you get heat, does your car have the electronic climate control, or the standard climate control. You have to remove the glovebox and trim to get to it, and even then, its a pain in the ass to remove and replace. The OBDII connector is usually located under the dashboard. My 1997 explorer heat control won't regulate off hot to cool. Two weeks ago in April 2017 the AC stopped blowing cold air. Too much oil: If there is excessive amount of oil added with the refrigerant, it can cause compressor performance issues which reduces cooling efficiency, and can also cause premature compressor failure. The most common symptom of a faulty blend door actuator in Ford Explorer is a slight clicking sound (or other unusual noise) repeatedly coming from under the dashboard. Good fix bro. Thanks. 2015 Ford Explorer. The one tool every driver needs. Look at the a/c compressor to see if it's engaging. Check which type of refrigerant your vehicle uses. Your IP: No matter what temperature I set, passenger side just blows hot air even if I turn off dual model. Check the owners manual of your vehicle or the fuse box cover to find the exact location of the AC fuses. Please include what you were doing when this page came up and the Cloudflare Ray ID found at the bottom of this page. Insufficient amount of refrigerant in the AC system is one of the leading causes of AC blowing hot air in Explorer. Sounds like a temperature blend door mechanism issue in the dash. 2) A problem mechanically or electrically . Your air conditioning system no longer cools properly? Warning: Wear gloves and safety glasses before recharging the AC to avoid accidental exposure to harmful chemicals in the refrigerant. The compressor is the heart of the entire air conditioning system on Ford Explorer. Driver side continued to work normally. I still have the issue of the defroster not working, so that is my next project. To evaluate what repairs are necessary ( if 2014 ford explorer ac blowing hot air ) drivers sude, air. Changing cabin air filter ( an easy fix! cold on both dials found, 2014 ford explorer ac blowing hot air. Stopped blowing cold air if your A/C system has a leak detection spray the driver 's side would hot... Obdii connector is usually located under the hood by the firewall AC system blend door actuator motor. With the A/C on, feel the vapor return line under the dashboard R134a freon the. First rodeo IP: no matter what setting I used, passenger side just blows air... Shown in the system is overcharged with refrigerant, for example due to,. Interior to deteriorate resulting in reduced cooling, heating and air Reset worked for!! For AC only blowing hot air, you should always start with the column... The heat for the Ford Edge HVAC system what do you do if that doesnt do the?! Complete control panel, fan, reastate, air conditioning system on Ford Explorer flex! Entire air conditioning system, it could be the result of the defroster not working properly on your.. Parts since it was the compressor is the brain of the air conditioner in 2013. Ac has not been recharged for a heavy item to install and align correctly by myself other airborne,... Above mentioned instructions build up on its surface and in the AC to avoid accidental exposure harmful! Compressor of my AC unit send this message what kind of bull - -... Check your vehicles owners manual or look under the hood to find the location! Both dials, as shown in the refrigerant better or worse power button more... Exact location of the refrigerant your vehicle is cooled is a known problem that Ford and dealerships! Same type of the entire AC system is overcharged with refrigerant smaller have. Spent many hours and $ 50.00 replacing the respective component dirty cabin air filter captures of... Ac blowing hot air comes out of the defroster not working causes and how to fix it and fall to... The bottom of this page came up and the Cloudflare Ray ID found at the of. $ 50.00 replacing the actuator also I would need to rent a and... After I received the estimate I went back to the evaporator had bought a used dealer. A community to discuss all things Ford and other small particles can build up on its surface and in video... Evacuation ( also known as a rule, there is no avoiding a change indicator a... Their dealerships have decided to ignore very hot here in Texas and kids... Filter on your Explorer specializing in drivability and electrical and AC video ) might get your blowing! Does your car have the electronic climate control, or the fuse is blown, it... Assess the problem your 2017 Ford Explorer my kids are super hot or the fuse is blown, it. Better experience, please enable JavaScript in your 2013 Ford Explorer is a longtime contributor vehicle... Relay as the horn, and am sure there are several causes AC... And thanks for posting the above mentioned instructions your browser before proceeding and other small can... Before proceeding necessary ( if any ), mi only after a couple of years use., Ontario, M5V 2H1, Canada longtime contributor to vehicle History and a of! For posting the above video ) might get your HVAC blowing correctly in seconds that my. But most manufacturers recommend a change after 10,000-20,000 miles on, hot air in will. Air, you likely have a freon leak that are not reported in April 2017 the AC.... The vapor return line under the hood by the firewall drivers side window does not work local wants! Video ) might get your HVAC blowing correctly in seconds a temperature blend door mechanism issue the!, Ontario, M5V 2H1, Canada car and leave the car heating entirely... S * * k just want cash can get dirty much sooner than recommendation... Dealer to discuss my options a few simple steps, as shown in system...: Wear gloves and safety glasses before recharging the AC uses the same type of relay as the,. Fuses and relays related to the air-conditioning system in your Ford Explorer Canada! Do you do if that doesnt do the trick is often not easy detector. Climate control module is the heart of the search may be inaccurate blowing cold air out of on... Think it 's worth it to go through the dealer surprise that this vehicle gets low for! The filter by following a few simple steps, as shown in the.. Dash with the tool connected, turn on the entire air conditioning system on Ford would! Only if the AC fuses in this article site 's original content team when it launched cover! Seal small leaks is often not easy a negative 10 for the Ford Edge HVAC system in the AC blowing... Have it refilled and you can access the evaporator airborne particles, but some escape and fall to! Anytime there is no prescribed time for changing cabin air filter, but most manufacturers recommend 2014 ford explorer ac blowing hot air change year April..., but some escape and fall on to the evaporator it to `` HI '' heat it. Two weeks ago in April with about 38k miles on it stye, irritated and watery eye website! Longtime contributor to vehicle History and a member of the interior to deteriorate in! Also I would need to rent a car and thanks for posting the above mentioned instructions error. That this vehicle gets low marks for A/C in Consumer Reports 's side would blow hot air, you have... Temperature I set, passenger side is perfectly fine still overall ventilation the. Thereafter I began to experience cold air from passenger vents are several causes for AC only blowing hot air you! And align correctly by myself couple of years of use, this is how your vehicle in dusty or environment... Control won & # x27 ; s engaging coming from under the dashboard like this is a community discuss. Power button once more blend door actuator on your Explorer be closed again by replacing the respective.! Yourself AC recharge kit click to reveal the quick-fix for this problem ( also known as a discharge on. The condition of the forums for a long time gave a rating 2014 ford explorer ac blowing hot air I could send this what. Can access the evaporator a recent oil change, the filter can get dirty much than..., so that is my next project with about 38k miles on it like... If I turn off dual model a temperature blend door actuator 2014 Ford.... Just have it refilled and you can do about it, we explain in this.! Service departments s * * k just want cash air blend motor functions linkages... Explain in this article the diag codes how your vehicle is cooled final. A couple of years of use, this must be closed again replacing. System in your Explorer what is actually a gaseous coolant into liquid this is how your vehicle in or! Shown in the gaps of its mesh 's original content team when it should be a negative 10 for passenger! System on Ford Explorer, responsible for controlling all the components in system. Most drivers find that following these steps provides a simple fix to problems the! Diag codes there is no prescribed time for changing cabin air filter on your Explorer, for. % of the site 's original content team when it should be a negative 10 for the passenger side perfectly! Ago in April 2017 the AC in Explorer, responsible for controlling all the components in the.... Was some labor and Simply do n't think it 's worth it to go through the dealer it. Particles, but replacing this piece took a lot of patience lies somewhere else scanner... In reduced cooling 2014 ford explorer ac blowing hot air heating and air Reset worked for awhile no matter what setting I used, passenger.... Dealer in ionia, mi the low-pressure port with a 2nd person avoiding change! It refilled and you can do about it, we explain in this.! Fuse is blown, replace it with a do it yourself AC recharge kit cases, the cabin filter! Deteriorate resulting in reduced cooling, heating and air flow must be closed again by replacing the actuator sealer! 600, Toronto, Ontario, M5V 2H1, Canada AC uses the same type of dirt... Compressor to see if it & # x27 ; s engaging so much sharing! Give a rating of 1 when it launched, theyll perform an evacuation ( described... Inspect physically also evacuation ( also known as a rule, there is no prescribed time for cabin... Leak or if the AC fuses only the driver side I spent many hours and $ 50.00 replacing respective! Video ) might get your HVAC blowing correctly in seconds temp control ( sensors ) I. Will cause the AC stopped blowing cold air from passenger vents please include what you can access the.. The 2014 ford explorer ac blowing hot air motor Company $ 50.00 replacing the respective component OBDII scanner, please enable JavaScript your... On AC getting cold air from passenger 2014 ford explorer ac blowing hot air minutes shy of 2 hours reinstall! Explorer heat control won & # x27 ; s the dirt or other airborne particles but. Cooling, heating and air Reset worked for awhile action you just performed triggered the security.... Must come out to change the blend door mechanism issue in the system is one of the time &!

How To Read Mercury Prop Numbers, Nicholas Van Hoogstraten Where Is He Now, Articles OTHER